Study on preparation of corn hydroxypropyl starch under ultrasound-microwave irradiation

HU Aijun; QIN Zhiping; ZHENG Jie; YANG Fei; DONG Li

您当前的位置：

首页 >

文章列表页 >

Study on preparation of corn hydroxypropyl starch under ultrasound-microwave irradiation

更新时间：2023-03-30

- Study on preparation of corn hydroxypropyl starch under ultrasound-microwave irradiation
- Journal of Radiation Research and Radiation Processing Vol. 27, Issue 1, Pages: 25-31(2009)
- 作者机构：
  
  1.天津天隆农业科技有限公司　天津　300457
  2.天津科技大学食品工程与生物技术学院，食品营养与安全省部共建教育部重点实验室　天津　300457
- 作者简介：
- 基金信息：
- DOI：
  CLC：
扫描看全文
HU Aijun, QIN Zhiping, ZHENG Jie, et al. Study on preparation of corn hydroxypropyl starch under ultrasound-microwave irradiation. [J]. Journal of Radiation Research and Radiation Processing 27(1):25-31(2009)
DOI：

HU Aijun, QIN Zhiping, ZHENG Jie, et al. Study on preparation of corn hydroxypropyl starch under ultrasound-microwave irradiation. [J]. Journal of Radiation Research and Radiation Processing 27(1):25-31(2009) DOI：

摘要

首先研究了超声处理时间、功率和淀粉浓度对玉米淀粉糊的黏度影响和超声处理后淀粉颗粒表面的变化，再将经超声处理的玉米淀粉与环氧丙烷在微波下进行醚化反应。与常规方法制备的羟丙基淀粉相比，超声-微波协同作用制备的玉米羟丙基淀粉（HPS）的摩尔取代度（MS）大大提高，反应时间明显缩短。超声处理淀粉后，淀粉的颗粒表面遭到一定程度的破坏，淀粉颗粒变得松散，更易于环氧丙烷与淀粉颗粒接触发生醚化反应。随着微波反应时间的增长，环氧丙烷用量的增加，淀粉的羟丙基摩尔取代度都有很大提高。并且增加淀粉浓度和微波的功率，淀粉的摩尔取代度先增大后减小。超声-微波协同作用制备羟丙基淀粉的优化工艺为：超声波功率600 W，超声时间25 min；微波功率100 W，微波时间14 min，淀粉乳浓度35%，环氧丙烷用量6.4%。

Abstract

In this article, some factors, such as ultrasound time, ultrasound power and starch concentration, affecting corn starch paste’s viscosity and morphology of starch particle are studied by use of ultrasound. The starch treated by ultrasound is used to prepare corn hydroxypropyl starch (HPS) with propylene oxide under microwave. Compared with conventional methods, ultrasonic-microwave method can improve HPS’s degree of molar substitution (MS) and sharply shorten reaction time. It is found that ultrasound can destruct surface morphology of starch particle, which can increase reaction efficiency as the particle becomes relax and easily to react with propylene oxide. HPS’s MS increases along with the reaction time and concentration of propylene oxide. With the increment of starch concentration and microwave power, the HPS’s MS increases at beginning and then decreases. The optimal parameters for HPS by use of ultrasonic-microwave irradiation are as followings: ultrasound power is 600 W, ultrasound-treated time is 25 min, microwave power is 100 W, microwave-treated time is 14 min, starch concentration is 35% and concentration of propylene oxide is 6.4%.

关键词

超声波微波羟丙基玉米淀粉（HPS）摩尔取代度（MS）

Keywords

UltrasoundMicrowaveCorn hydroxypropyl starch(HPS)Degree of molar substitution (MS)

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Biological effects of 2450 MHz microwave combined with γ-rays on rat cultured gliacytes

The detection of hot water extraction from paper raw material using microwave technology

The reduction of γ-rays damages of mice hematopoietic system pre-treated by low dose microwave irradiation

The influence of microwave irradiation during lactation and gestation on the role of thyroid hormone in dysfunction of learning and memory with mice

Inhibitory effect of microwave exposure on the import of mitochondrial transcription factor A (Tfam)

Related Author

No data

Related Institution

Changzhou Center for Disease and Control Prevention

School of Radiation Medicine and Public Health, Suzhou University

College of Science, Tianjin University of Science and Technology

College of Chemical Engineering, Tianjin University of Science and Technology

Department of Toxicology, School of Radiation Medicine and Public Health, Soochow University

⁰