Radiation-induced grafting of ethyl styrenesulfonate onto polyvinylidene fluoride resin

Yicheng WANG; Jing PENG; Xinmiao ZENG; Jiuqiang LI; Maolin ZHAI

doi:10.11889/j.1000-3436.2016.rrj.34.050301

您当前的位置：

首页 >

文章列表页 >

Radiation-induced grafting of ethyl styrenesulfonate onto polyvinylidene fluoride resin

RADIATION CHEMISTRY | 更新时间：2021-12-10

- Radiation-induced grafting of ethyl styrenesulfonate onto polyvinylidene fluoride resin
- Journal of Radiation Research and Radiation Processing Vol. 34, Issue 5, (2016)
- 作者机构：
  
  1.北京大学化学与分子工程学院, 放射化学与辐射化学重点学科实验室, 教育部高分子化学与物理重点实验室, 北京分子科学国家实验室北京 100871
  2.北京市射线应用研究中心辐射新材料北京市重点实验室北京 100015
- 作者简介：
- 基金信息：
  
  Beijing Natural Science Foundation(2132031);"NSAF" joint fund(U1430234)
- DOI：10.11889/j.1000-3436.2016.rrj.34.050301
  CLC：
扫描看全文
Yicheng WANG, Jing PENG, Xinmiao ZENG, et al. Radiation-induced grafting of ethyl styrenesulfonate onto polyvinylidene fluoride resin. [J]. Journal of Radiation Research and Radiation Processing 34(5):050301-7(2016)
DOI：

Yicheng WANG, Jing PENG, Xinmiao ZENG, et al. Radiation-induced grafting of ethyl styrenesulfonate onto polyvinylidene fluoride resin. [J]. Journal of Radiation Research and Radiation Processing 34(5):050301-7(2016) DOI： 10.11889/j.1000-3436.2016.rrj.34.050301.

摘要

以聚偏氟乙烯（Polyvinylidene fluoride，PVDF）树脂为基材，采用γ射线预辐射接枝法在PVDF树脂上接枝苯乙烯磺酸乙酯（Ethyl styrenesulfonate，ETSS），探讨吸收剂量、接枝温度、接枝反应时间及单体浓度对接枝率的影响。之后在95℃水解PVDF-g-PETSS聚合物得到PVDF接枝苯乙烯磺酸（PVDF-g-PSSA）离子交换树脂。红外光谱、X射线光电子能谱、热重分析证明PVDF-g-PETSS及PVDF-g-PSSA被成功制备。当接枝率为120%时，PVDF-g-PSSA的离子交换容量达到2.05 mmol/g。这种将带有磺酸基团的单体通过辐照接枝引入PVDF基材然后水解的方法简单、高效、污染小，有望在离子交换树脂及离子交换膜的制备中得到应用。

Abstract

Polyvinylidene fluoride (PVDF) resin was used as the substrate, and grafted with ethyl styrenesulfo-nate (ETSS) monomer through pre-irradiation graft polymerization method. The influence of absorbed dose, grafting temperature, reaction time, and concentration of ETSS monomer on grafting yield (,R,g,) were investigated. After that, the PVDF-g-PSSA ion exchange resin was obtained ,via, hydrolysis of PVDF-g-PETSS at 95 oC. The grafting of ETSS and preparation of PVDF-g-PSSA were proved by FTIR, XPS and TGA. At the ,R,g, of 120%, the ion exchange capacity of PVDF-g-PSSA reached 2.05 mmol/g. This work provides a facile route for the preparation of ion exchange resin.

关键词

离子交换树脂聚偏氟乙烯苯乙烯磺酸乙酯辐射接枝

Keywords

Ion exchange resinPolyvinylidene fluorideEthyl styrenesulfonateRadiation-induced graft

references

P Hinksman , D H Isaac , P Morrissey . Environmental stress cracking of poly (vinylidene fluoride) and welds in alkaline solutions . Polymer Degradation and Stability , 2000 . 68 (2 ):299 -305 . DOI:10.1016/S0141-3910(00)00015-Xhttp://doi.org/10.1016/S0141-3910(00)00015-X .

M L Yeow , Y Liu , K Li . Preparation of porous PVDF hollow fibre membrane via a phase inversion method using lithium perchlorate (LiClO4) as an additive . Journal of Membrane Science , 2005 . 258 (1-2 ):16 -22 . DOI:10.1016/j.memsci.2005.01.015http://doi.org/10.1016/j.memsci.2005.01.015 .

B A Gorelik , M B Voskobojnic . Flexible highly filled coatings based on PVDF . Journal of Fluorine Chemistry , 2000 . 104 (1 ):73 -77 . DOI:10.1016/S0022-1139(00)00229-3http://doi.org/10.1016/S0022-1139(00)00229-3 .

W P Kosar , J J Morris . A functional fluoropolymer powder coating for chemical process applications . Journal of Coatings Technology and Research , 2007 . 4 (1 ):51 -58 . DOI:10.1007/s11998-007-9009-0http://doi.org/10.1007/s11998-007-9009-0 .

M Gryta , K Karakulski , A W Morawski . Purification of oily wastewater by hybrid UF/MD . Water Research , 2001 . 35 (15 ):3665 -3669 . DOI:10.1016/S0043-1354(01)00083-5http://doi.org/10.1016/S0043-1354(01)00083-5 .

A L Ahmad , S Ismail , S Bhatia . Membrane treatment for palm oil mill effluent: effect of transmembrane pressure and crossflow velocity . Desalination , 2005 . 179 (1-3 ):245 -255 . DOI:10.1016/j.desal.2004.11.071http://doi.org/10.1016/j.desal.2004.11.071 .

A Mokrini , M A Huneault , P Gerard . Partially fluorinated proton exchange membranes based on PVDF-SEBS blends compatibilized with methylmethacrylate block copolymers . Journal of Membrane Science , 2006 . 283 (1-2 ):74 -83 . DOI:10.1016/j.memsci.2006.06.032http://doi.org/10.1016/j.memsci.2006.06.032 .

G G Kumar , P Kim , K S Nahm , 等 . Structural characterization of PVdF-HFP/PEG/Al2O3 proton conduc-ting membranes for fuel cells . Journal of Membrane Science , 2007 . 303 (1-2 ):126 -131 . DOI:10.1016/j.memsci.2007.06.069http://doi.org/10.1016/j.memsci.2007.06.069 .

Z Y Cui , Y Y Xu , L P Zhu , 等 . Preparation of PVDF/PEO-PPO-PEO blend microporous membranes for lithium ion batteries via thermally induced phase separation process . Journal of Membrane Science , 2008 . 325 (1-2 ):957 -963 . DOI:10.1016/j.memsci.2008.09.022http://doi.org/10.1016/j.memsci.2008.09.022 .

杜纪富 , 董珍 , 谢聪 , 等 . 辐射接枝技术在吸附材料制备中的应用 . 高分子学报 , 2016 . 6 698 -705 . http://www.cnki.com.cn/Article/CJFDTOTAL-GFXB201606003.htmhttp://www.cnki.com.cn/Article/CJFDTOTAL-GFXB201606003.htm, .

Jifu DU , Zhen DONG , Cong XIE , 等 . Application of Radiation Grafting Technique in Preparation of Adsorption Materials . Acta Polymerica Sinica , 2016 . 6 698 -705 . http://www.cnki.com.cn/Article/CJFDTOTAL-GFXB201606003.htmhttp://www.cnki.com.cn/Article/CJFDTOTAL-GFXB201606003.htm, .

M M Nasef . Radiation-grafted membranes for polymer electrolyte fuel cells: current trends and future directions . Chemical Reviews , 2014 . 114 (24 ):12278 -12329 . DOI:10.1021/cr4005499http://doi.org/10.1021/cr4005499 .

J Chen , M Asano , Y Maekawa , 等 . Suitability of some fluoropolymers used as base films for preparation of polymer electrolyte fuel cell membranes . Journal of Membrane Science , 2006 . 277 (1-2 ):249 -257 . DOI:10.1016/j.memsci.2005.10.036http://doi.org/10.1016/j.memsci.2005.10.036 .

B Deng , M Yu , X Yang , 等 . Antifouling microfiltration membranes prepared from acrylic acid or methacrylic acid grafted poly (vinylidene fluoride) powder synthesized via pre-irradiation induced graft polymerization . Journal of Membrane Science , 2010 . 350 (1-2 ):252 -278 . DOI:10.1016/j.memsci.2009.12.035http://doi.org/10.1016/j.memsci.2009.12.035 .

M Yu , B Zhang , B Deng , 等 . Preirradiation-induced emulsion graft polymerization of glycidyl methacrylate onto poly (vinylidene fluoride) powder . Journal of Applied Polymer Science , 2010 . 117 (6 ):3575 -3581 . DOI:10.1002/app.32288http://doi.org/10.1002/app.32288 .

X Yang , B Deng , Z Liu , 等 . Microfiltration membranes prepared from acryl amide grafted poly (vinylidene fluoride) powder and their pH sensitive behaviour . Journal of Membrane Science , 2010 . 362 (1-2 ):298 -305 . DOI:10.1016/j.memsci.2010.06.057http://doi.org/10.1016/j.memsci.2010.06.057 .

吉玉玲 , 李林繁 , 于洋 , 等 . 粉体PVDF辐射接枝苯乙烯 . 辐射研究与辐射工艺学报 , 2009 . 27 (2 ):79 -83 . http://www.cnki.com.cn/Article/CJFDTotal-FYFG200902004.htmhttp://www.cnki.com.cn/Article/CJFDTotal-FYFG200902004.htm, .

Yuling JI , Linfan LI , Yang YU , 等 . Radiation grafting of styrene into PVDF powder . Journal of Radiation Research and Radiation Processing , 2009 . 27 (2 ):79 -83 . http://www.cnki.com.cn/Article/CJFDTotal-FYFG200902004.htmhttp://www.cnki.com.cn/Article/CJFDTotal-FYFG200902004.htm, .

C Xing , Y Wang , C Zhang , 等 . Immobilization of ionic liquids onto the poly (vinylidene fluoride) by electron beam irradiation . Industrial & Engineering Chemistry Research , 2015 . 54 (38 ):9351 -9359 . DOI:10.1021/acs.iecr.5b02819http://doi.org/10.1021/acs.iecr.5b02819 .

C Xing , J Guan , Y Li , 等 . Effect of a room-temperature ionic liquid on the structure and properties of electrospun poly(vinylidene fluoride) nanofibers . ACS Applied Materials & Interfaces , 2014 . 6 (6 ):4447 -4457 . DOI:10.1021/am500061vhttp://doi.org/10.1021/am500061v .

C Xing , J Guan , Z Chen , 等 . Novel multifunctional nanofibers based on thermoplastic polyurethane and ionic liquid: towards antibacterial, anti-electrostatic and hydrophilic nonwovens by electrospinning . Nanotech-nology , 2015 . 26 105704 DOI:10.1088/0957-4484/26/10/105704http://doi.org/10.1088/0957-4484/26/10/105704 .

马骏 , 胡国文 , 彭静 , 等 . PVDF基两性离子交换树脂的辐射合成及性能 . 高分子学报 , 2012 . 12 (11 ):1276 -1282 . DOI:10.3724/SP.J.1105.2012.12043http://doi.org/10.3724/SP.J.1105.2012.12043 .

Jun MA , Guowen HU , Jing PENG , 等 . Characterization of amphoteric ion exchange resin prepared by radiation-induced grafting polymerization . Acta Polymerica Sinica , 2012 . 12 (11 ):1276 -1282 . DOI:10.3724/SP.J.1105.2012.12043http://doi.org/10.3724/SP.J.1105.2012.12043 .

J Ma , Y Wang , J Peng , 等 . Designing a new process to prepare amphoteric ion exchange membrane with well-distributed grafted chains for vanadium redox flow battery . Journal of Membrane Science , 2012 . 419 1 -8 . DOI:10.1016/j.memsci.2012.04.034http://doi.org/10.1016/j.memsci.2012.04.034 .

J Yuan , C H Yu , J Peng , 等 . Facile synthesis of amphoteric ion exchange membrane by radiation grafting of sodium styrene sulfonate and N, N-dimethylaminoethyl methacrylate for vanadium redox flow battery . Journal of Polymer Science Part A , 2013 . 51 (24 ):5194 -5202 . DOI:10.1002/pola.26949http://doi.org/10.1002/pola.26949 .

J Chen , M Asano , Y Maekawa , 等 . Fuel cell performance of polyetheretherketone-based polymer electrolyte membranes prepared by a two-step grafting method . Journal of Membrane Science , 2008 . 319 (1-2 ):1 -4 . DOI:10.1016/j.memsci.2008.03.046http://doi.org/10.1016/j.memsci.2008.03.046 .

G Laruelle , E Nicol , E Ameduri , 等 . Synthesis of poly (vinylidene fluoride)-b-poly (styrene sulfonate) block copolymers by controlled radical polymerizations . Journal of Polymer Science Part A , 2011 . 49 (18 ):3960 -3969 . DOI:10.1002/pola.24836http://doi.org/10.1002/pola.24836 .

A Hebeish , M K Zahran , M H El-Rafie , 等 . Preparation and characterisation of poly (acrylic acid) starch polyblends . Polymers & Polymer Composites , 1996 . 4 (2 ):129 -141 . http://cn.bing.com/academic/profile?id=2524452327&encoded=0&v=paper_preview&mkt=zh-cnhttp://cn.bing.com/academic/profile?id=2524452327&encoded=0&v=paper_preview&mkt=zh-cn, .

J Y Qiu , J Z Zhang , J H Chen , 等 . Performance of vanadium redox flow battery with a novel amphoteric ion exchange membrane synthesized by two-step grafting method . Journal of Membrane Science , 2009 . 342 (1-2 ):215 -220 . DOI:10.1016/j.memsci.2009.06.043http://doi.org/10.1016/j.memsci.2009.06.043 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

THE RADIATION EFFECTS OF POLYVINYLIDENE FLUORIDE AND ITS TEMPERATURE DEPENDENCE

Related Author

No data

Related Institution

Changchun Institute of Applied Chemistry, Academia Sinica

⁰