Effects of electron beam irradiation grafting on anti-wrinkle/water and oil repellency of cotton fabric

Haihong QIAN; Hongbo WANG; Jiajia FU; Taiqiu CHEN; Chunyan JIANG

doi:10.11889/j.1000-3436.2017.rrj.35.020301

您当前的位置：

首页 >

文章列表页 >

Effects of electron beam irradiation grafting on anti-wrinkle/water and oil repellency of cotton fabric

RADIATION CHEMISTRY | 更新时间：2021-12-10

- Effects of electron beam irradiation grafting on anti-wrinkle/water and oil repellency of cotton fabric
- Journal of Radiation Research and Radiation Processing Vol. 35, Issue 2, Pages: 20301(2017)
- 作者机构：
  
  1.江苏省功能纺织品工程技术研究中心江南大学无锡 214122
  2.生态纺织教育部重点实验室江南大学无锡 214122
  3.圣华盾防护科技股份有限公司无锡 214122
- 作者简介：
- 基金信息：
  
  Supported by the Industry-academic Joint Technological Prospective Fund Project of Jiangsu Province(BY2016022-23);and Advanced Textile Engineering Technology Center Project of Jiangsu Province(XJFZ/2015/1)
- DOI：10.11889/j.1000-3436.2017.rrj.35.020301
  CLC：
扫描看全文
Haihong QIAN, Hongbo WANG, Jiajia FU, et al. Effects of electron beam irradiation grafting on anti-wrinkle/water and oil repellency of cotton fabric. [J]. Journal of Radiation Research and Radiation Processing 35(2):20301(2017)
DOI：

Haihong QIAN, Hongbo WANG, Jiajia FU, et al. Effects of electron beam irradiation grafting on anti-wrinkle/water and oil repellency of cotton fabric. [J]. Journal of Radiation Research and Radiation Processing 35(2):20301(2017) DOI： 10.11889/j.1000-3436.2017.rrj.35.020301.

摘要

利用MG-6600型拒水拒油剂以及柠檬酸抗皱剂，以轧烘焙、电子束辐照接枝、等离子体预处理-电子束辐照接枝三种工艺对棉织物进行后整理。傅里叶红外光谱（FTIR）证明拒水拒油剂与柠檬酸已成功接枝于棉纤维上；扫描电子显微镜（SEM）分析表明经三种工艺整理后的棉织物表面均有一层覆盖物，且经等离子预处理后的织物表面出现纵向条纹。通过测量棉织物折皱回复角（WRA）、对水的接触角（WCA）、对油（正十六烷）的接触角（OCA）大小来表征织物性能的变化。结果表明，在等离子体预处理-电子束辐照接枝工艺条件下，棉织物的抗皱、拒水、拒油性能达到最优，其WRA为185.9°，WCA为158.9°，OCA为129.1°，断裂强力、白度值均能满足服用要求，同时棉织物的耐水洗性能大大提高。

Abstract

MG-6600 and citric acid were used as a water and oil repellent and as an anti-wrinkle agent, respectively. Cotton fabrics were subjected to one of the following three processes: (1) the pad-dry-cure process, (2) electron beam irradiation grafting, and (3) plasma pretreatment, followed by electron beam irradiation grafting. Fourier transform infrared spectroscopy (FTIR) proved that MG-6600 and citric acid were successfully grafted onto the cotton fiber. Scanning electron microscopy showed that the surfaces of the three types of treated cotton fabrics were covered by layers. Further, longitudinal stripes appeared on the surface of the fabric subjected to plasma pre-treatment. The change in the cotton fabric properties was characterized by measuring the wrinkle recovery angle (WRA), the contact angle (WCA), and the contact angle to oil (,n,-hexadecane) (OCA). The results showed that the wrinkle resistance and the water and oil repellency were optimized when the fabric was subjected to plasma pretreatment and electron beam irradiation: the WRA, WCA, and OCA were 185.9°, 158.9°, and 129.1°. Further, the breaking strength and whiteness of the cotton fabric met the requirements of the apparel standards, and the washing durability of cotton fabric was significantly enhanced.

关键词

棉织物电子束辐照接枝等离子体预处理抗皱整理拒水拒油整理

Keywords

Cotton fabricElectron beam irradiation graftingPlasma pre-treatmentAnti-wrinkle finishingWater and oil repellent finishing

references

汪津 , 纪柏林 , 胡婷莉 , 等 . 棉织物多元羧酸抗皱整理免水洗工艺 . 纺织学报 , 2015 . 36 (10 ):92 -96 . DOI:10.13475/j.fzxb.20141005905http://doi.org/10.13475/j.fzxb.20141005905 .

Jin WANG , Bolin JI , Tingli HU , 等 . Washing-free anti-wrinkle finishing of cotton fabric by polycarboxylic acid . Journal of Textile Research , 2015 . 36 (10 ):92 -96 . DOI:10.13475/j.fzxb.20141005905http://doi.org/10.13475/j.fzxb.20141005905 .

谢全焕. 新型拒水拒油含氟整理剂的合成及应用[D]. 上海: 东华大学. 2014.

XIE Quanhuan. The synthesis and application of novel fluorine containing water-and oil-repellent[D]. Shanghai: Donghua University. 2014.

R Davis , A El-Shafei , P Hauser . Use of atmospheric pressure plasma to confer durable water repellent functionality and antimicrobial functionality on cotton/polyester blend . Surface & Coatings Technology , 2011 . 205 (4 ):4791 -4797 . DOI:10.1016/j.surfcoat.2011.04.035http://doi.org/10.1016/j.surfcoat.2011.04.035 .

W Tang , Y Huang , F L Qing . Synthesis and characterization of fluorinated polyacrylate graft copolymers capable as water and oil repellent finishing agents . Journal of Applied Polymer Science , 2011 . 119 (1 ):84 -92 . DOI:10.1002/app.32605http://doi.org/10.1002/app.32605 .

李智斌 , 樊增禄 , 毛宁涛 , 等 . 氟硅无皂拒水剂在棉织物拒水整理中的应用 . 西安工程大学学报 , 2016 . 30 (1 ):21 -27 . DOI:10.13338/j.issn.1674-649x.2016.01.004http://doi.org/10.13338/j.issn.1674-649x.2016.01.004 .

Zhibin LI , Zenglu FAN , Ningtao MAO , 等 . Study of water repellent finishing on cotton with fluorosilicon soap-free water repellent agent . Journal of Xi'an Polytechnic University , 2016 . 30 (1 ):21 -27 . DOI:10.13338/j.issn.1674-649x.2016.01.004http://doi.org/10.13338/j.issn.1674-649x.2016.01.004 .

刘金云. 以柠檬酸为交联剂的溶胶—凝胶法超拒水整理耐久性研究[D]. 东华大学, 2011. DOI: 10.7666/d.y2135482.http://dx.doi.org/10.7666/d.y2135482.

LIU Jinyun. Preparation of durable superhydrophobic surface by sol.gel method with citric acid as crosslinking agent[D]. Donghua University, 2011. DOI: 10.7666/d.y2135482.http://dx.doi.org/10.7666/d.y2135482.

W Yao , B Wang , T Ye , 等 . Durable press finishing of cotton fabrics with citric acid: enhancement of whiteness and wrinkle recovery by polyol extenders . Industrial & Engineering Chemistry Research , 2013 . 52 (46 ):16118 -16127 . DOI:10.1021/ie402747xhttp://doi.org/10.1021/ie402747x .

高冬梅 , 宋晓秋 , 李宏涛 . 棉织物的多元羧酸抗皱整理 . 印染 , 2005 . 31 (5 ):7 -8 . DOI:10.3321/j.issn:1000-4017.2005.05.003http://doi.org/10.3321/j.issn:1000-4017.2005.05.003 .

Dongmei GAO , Xiaoqiu SONG , Hongtao LI . DP finish of cotton fabric . Dyeing and Finishing , 2005 . 31 (5 ):7 -8 . DOI:10.3321/j.issn:1000-4017.2005.05.003http://doi.org/10.3321/j.issn:1000-4017.2005.05.003 .

张维 , 李鹏飞 , 杜建功 . 柠檬酸/乙二醇的棉织物抗皱整理 . 印染 , 2009 . 35 (24 ):15 -17 . http://www.cnki.com.cn/Article/CJFDTOTAL-YIRA200924004.htmhttp://www.cnki.com.cn/Article/CJFDTOTAL-YIRA200924004.htm, .

Wei ZHANG , Pengfei LI , Jiangong DU . Anti-crease finish of cotton fabric with citric acid/glycol . Dyeing and Finishing , 2009 . 35 (24 ):15 -17 . http://www.cnki.com.cn/Article/CJFDTOTAL-YIRA200924004.htmhttp://www.cnki.com.cn/Article/CJFDTOTAL-YIRA200924004.htm, .

X Liu , T Xing , D Xu . Study on silk anti-crease finishing with polycarboxyl-terminated trichlorotriazine derivatives by surface analysis methods . Applied Surface Science , 2012 . 261 (3 ):255 -261 . DOI:10.1016/j.apsusc.2012.07.156http://doi.org/10.1016/j.apsusc.2012.07.156 .

J Wu , J Li , B Deng , 等 . Self-healing of the superhydrophobicity by ironing for the abrasion durable superhydrophobic cotton fabrics . Scientific Reports , 2013 . 3 2951 DOI:10.1038/srep02951http://doi.org/10.1038/srep02951 .

S U Islam , F Mohammad . High-energy radiation induced sustainable coloration and functional finishing of textile materials . Industry & Engineering Chemistry Research , 2015 . 54 (3 ):3727 -3745 . DOI:10.1021/acs.iecr.5b00524http://doi.org/10.1021/acs.iecr.5b00524 .

A Ceria , P J Hauser . Atmospheric plasma treatment to improve durability of a water and oil repellent finishing for acrylic fabrics . Surface & Coatings Technology , 2010 . 204 (9 ):1535 -1541 . DOI:10.1016/j.surfcoat.2009.09.077http://doi.org/10.1016/j.surfcoat.2009.09.077 .

E Nithya , R Radhai , R Rajedran , 等 . Enhancement of the antimicrobial property of cotton fabric using plasma and enzyme preatment . Carbohydrate Polymers , 2012 . 88 (1 ):986 -991 . DOI:10.1016/j.carbpol.2012.01.049http://doi.org/10.1016/j.carbpol.2012.01.049 .

S Zanini , S Freti , A Citterio , 等 . Characterization of hydro-and oleo-repellent pure cashmere and wool/nylon textiles obtained by atmospheric pressure plasma pre-treatment and coating with a fluorocarbon resin . Surface & Coatings Technology , 2016 . 292 (3 ):155 -160 . DOI:10.1016/j.surfcoat.2016.03.020http://doi.org/10.1016/j.surfcoat.2016.03.020 .

朱春波 , 蒋学 , 王鸿博 , 等 . 辐照接枝改性涤纶织物的亲水性能 . 辐射研究与辐射工艺学报 , 2016 . 34 (3 ):33 -39 . DOI:10.11889/j.1000-3436.2016.rrj.34.030302http://doi.org/10.11889/j.1000-3436.2016.rrj.34.030302 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract310.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract310.shtml, .

Chunbo ZHU , Xue JIANG , Hongbo WANG , 等 . Hydrophilic property of polyester fabric modified by irradiation grafting . Journal of Radiation Research and Radiation Processing , 2016 . 34 (3 ):33 -39 . DOI:10.11889/j.1000-3436.2016.rrj.34.030302http://doi.org/10.11889/j.1000-3436.2016.rrj.34.030302 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract310.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract310.shtml, .

王蕾 , 刘建立 , 高卫东 . 基于视频序列的织物折皱回复角动态测量 . 纺织学报 , 2013 . 34 (2 ):55 -60 . DOI:10.3969/j.issn.0253-9721.2013.02.010http://doi.org/10.3969/j.issn.0253-9721.2013.02.010 .

Lei WANG , Jianli LIU , Weidong GAO . Dynamic measurement of fabric wrinkle recovery angle by video sequence . Journal of Textile Research , 2013 . 34 (2 ):55 -60 . DOI:10.3969/j.issn.0253-9721.2013.02.010http://doi.org/10.3969/j.issn.0253-9721.2013.02.010 .

单良 , 李战雄 , 臧雄 , 等 . 核壳型含氟丙烯酸酯乳液的合成及其在棉织物整理中的应用 . 纺织学报 , 2015 . 36 (1 ):123 -128 . DOI:10.13475/j.fzxb.201501012306http://doi.org/10.13475/j.fzxb.201501012306 .

Liang SHAN , Zhanxiong LI , Xiong ZANG , 等 . Synthesis of fluoro-acrylate emulsion with core-shell structure and its application on cotton fabric finishing . Journal of Textile Research , 2015 . 36 (1 ):123 -128 . DOI:10.13475/j.fzxb.201501012306http://doi.org/10.13475/j.fzxb.201501012306 .

H Qi , J B Pan , F L Qing , 等 . Anti-wrinkle and UV protective performance of cotton fabrics finished with 5-(carbonyl oxy succinic)-benzene-1, 2, 4-tricarboxylic acid . Carbohydrate Polymers , 2016 . 154 (6 ):313 -319 . DOI:10.1016/j.carbpol.2016.05.108http://doi.org/10.1016/j.carbpol.2016.05.108 .

张严 , 李永强 , 邵建中 , 等 . 氦等离子体接枝聚合棉织物的疏水改性 . 纺织学报 , 2016 . 37 (7 ):99 -103 . DOI:10.13475/j.fzxb.20150602905http://doi.org/10.13475/j.fzxb.20150602905 .

Yan ZHANG , Yongqiang LI , Jianzhong SHAO , 等 . Hydrophobic modification of cotton fabric by helium low temperature plasma induced graft polymerization . Journal of Textile Research , 2016 . 37 (7 ):99 -103 . DOI:10.13475/j.fzxb.20150602905http://doi.org/10.13475/j.fzxb.20150602905 .

C H Dong , Z Lu , F J Zhang , 等 . Preparation and properties of cotton fabrics treated with a novel polysiloxane water repellent and flame retardant . Materials Letters , 2015 . 152 (4 ):276 -279 . DOI:10.1016/j.matlet.2015.03.132http://doi.org/10.1016/j.matlet.2015.03.132 .

T Textor , B Mahltig . A sol-gel based surface treatment for preparation of water repellent antistatic textiles . Applied Surface Science , 2010 . 256 (10 ):1668 -1674 . DOI:10.1016/j.apsusc.2009.09.091http://doi.org/10.1016/j.apsusc.2009.09.091 .

B Deng , R Cai , Y Yu , 等 . Laundering durability of superhydrophobic cotton fabric . Advanced Materials , 2010 . 22 (48 ):5473 DOI:10.1002/adma.201002614http://doi.org/10.1002/adma.201002614 .

M Mohsin , N Sarwar , S Ahmad , 等 . Maleic acid crosslinking of C-6 fluorocarbon as oil and water repellent finish on cellulosic fabrics . Journal of Cleaner Production , 2016 . 112 (10 ):3525 -3530 . DOI:10.1016/j.jclepro.2015.10.045http://doi.org/10.1016/j.jclepro.2015.10.045 .

李建喜 , 单永东 , 张聪 , 等 . 电子束辐照乙烯-四氟乙烯共聚物的化学稳定性 . 辐射研究与辐射工艺学报 , 2015 . 34 (6 ):25 -30 . DOI:10.11889/j.1000-3436.2015.rrj.33.060301http://doi.org/10.11889/j.1000-3436.2015.rrj.33.060301 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract271.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract271.shtml, .

Jianxi LI , Yongdong SHAN , Cong ZHANG , 等 . Chemical stability of ethylene-tetra-fluoro-ethylene irradiated by electron beam . Journal of Radiation Research and Radiation Processing , 2015 . 34 (6 ):25 -30 . DOI:10.11889/j.1000-3436.2015.rrj.33.060301http://doi.org/10.11889/j.1000-3436.2015.rrj.33.060301 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract271.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract271.shtml, .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Preparation of reactive flame retardant dimethly allylphosphonate and its grafting onto cotton fabric via ultraviolet light irradiation

Preparation of N-halamine treated antibacterial cotton fabric via UV irradiation

Hydrophobic property of cotton-fabric modified by electron-beam irradiation

Related Author

No data

Related Institution

School of Textile and Garment, Nantong University

School of Textile and Garment, Yancheng Institute of Technology

School of Textile and Garment, Xi'an Polytechnic University

Key Laboratory of Eco-textiles, Ministry of Education, Jiangnan University

Jiangsu Engineering Technology Research Center for Functional Textiles, Jiangnan University

⁰