Preparation of nano-cellulose by electron beam radiation

Guoshi CUI; Bei YANG; Hongying ZHAO; Xingjuan SHU; Ru FAN

doi:10.11889/j.1000-3436.2018.rrj.36.050302

您当前的位置：

首页 >

文章列表页 >

Preparation of nano-cellulose by electron beam radiation

RADIATION CHEMISTRY | 更新时间：2021-12-10

- Preparation of nano-cellulose by electron beam radiation
- Journal of Radiation Research and Radiation Processing Vol. 36, Issue 5, (2018)
- 作者机构：
  
  1.河南科高辐射化工科技有限公司洛阳 471000
  2.河南省辐射化学新材料重点实验室洛阳 471000
- 作者简介：
- 基金信息：
  
  Science and Technology Innovation Talent Project of Henan Province(184200510025);Pre-research Project of Henan Academy of Sciences(豫财预[2016]80号)
- DOI：10.11889/j.1000-3436.2018.rrj.36.050302
  CLC：
扫描看全文
Guoshi CUI, Bei YANG, Hongying ZHAO, et al. Preparation of nano-cellulose by electron beam radiation. [J]. Journal of Radiation Research and Radiation Processing 36(5):050302-5(2018)
DOI：

Guoshi CUI, Bei YANG, Hongying ZHAO, et al. Preparation of nano-cellulose by electron beam radiation. [J]. Journal of Radiation Research and Radiation Processing 36(5):050302-5(2018) DOI： 10.11889/j.1000-3436.2018.rrj.36.050302.

摘要

以纤维素浆粕为原料，经电子束辐照降解、湿法磨浆、高压均质处理，成功制备出纳米纤维素分散液。结果表明，纳米纤维素制备优化工艺为：纤维分散液质量分数为2%，磨浆次数为5次，NaOH质量分数为5%，吸收剂量为100 kGy，由此制备出的纳米纤维素直径在60 nm左右，长度为1 μm左右。

Abstract

Cellulose pulp was used as raw material and a nano-cellulose dispersion was successfully prepared via electron beam radiation degradation, wet refining, and high-pressure homogenization treatment. The results showed that the parameters in the nano-cellulose preparation optimization process were as follows:the fiber dispersion concentration was 2%, refining frequency was 5 times, alkali concentration was 5%, and absorbed dose was 100 kGy. The diameter and length of the prepared nano-cellulose were approximately 60 nm and 1 μm, respectively.

关键词

电子束辐照降解纳米纤维素

Keywords

Electron beam radiationDegradationNano-cellulose

references

吴清林 , 梅长彤 , 韩景泉 , 等 . 纳米纤维素制备技术及产业化现状 . 林业工程学报 , 2018 . 3 (1 ):1 -9 . DOI:10.13360/j.issn.2096-1359.2018.01.001http://doi.org/10.13360/j.issn.2096-1359.2018.01.001 .

Qinglin WU , Changtong MEI , Jingquan HAN , 等 . Preparation technology and industrization status of nanocellulose . Jouranl of Forestry Engineering , 2018 . 3 (01 ):1 -9 . DOI:10.13360/j.issn.2096-1359.2018.01.001http://doi.org/10.13360/j.issn.2096-1359.2018.01.001 .

李逸 , 王可鑫 , 郑卓辉 , 等 . 纳米纤维素复合材料的应用进展 . 纸和造纸 , 2016 . 35 (12 ):26 -28 . DOI:10.13472/j.ppm.2016.12.007http://doi.org/10.13472/j.ppm.2016.12.007 .

Yi LI , Kexin WANG , Zhuohui ZHENG , 等 . Application progress of nano-cellulose composites . Paper and Paper Making , 2016 . 35 (12 ):26 -28 . DOI:10.13472/j.ppm.2016.12.007http://doi.org/10.13472/j.ppm.2016.12.007 .

徐威宇.植物纤维原料制备纳米纤维素的研究[D].广州: 华南理工大学, 2016.

XU Weiyu. The research of nanocellulose fiber raw material[D]. Guangzhou: South China University of Technology, 2016.

孙启伟.绿色法制备纳米木薯渣及其在橡胶复合体系的应用初探[D].南宁: 广西大学, 2017.

SUN Qiwei. Green fabrication of nano cassava dregs and its potential application in rubber[D]. Nanning: Guangxi University, 2017.

欧华杰 , 陈港 , 蒋晨颖 , 等 . NMMO预处理制备微纳米纤维素及其在纸页增强中的应用 . 造纸科学与技术 , 2017 . 36 (6 ):57 -60 . DOI:10.19696/j.issn1671-4571.2017.06.013http://doi.org/10.19696/j.issn1671-4571.2017.06.013 .

Huajie OU , Gang CHEN , Chenying JIANG , 等 . Preparation of cellulose nanofibrils and its application in paper coating . Paper Science & Technology , 2017 . 36 (6 ):57 -60 . DOI:10.19696/j.issn1671-4571.2017.06.013http://doi.org/10.19696/j.issn1671-4571.2017.06.013 .

申玲玲 , 张放 , 任浩 , 等 . 氧化纤维对纳米纤维素气凝胶微球的影响 . 纤维素科学与技术 , 2017 . 25 (3 ):1 -7 . DOI:10.16561/j.cnki.xws.2017.03.02http://doi.org/10.16561/j.cnki.xws.2017.03.02 .

Lingling SHEN , Fang ZHANG , Hao REN , 等 . Effect of oxidized fibril on cellulose nanofiber based aerogel microsphere . Journal of Cellulose Science and Technology , 2017 . 25 (3 ):1 -7 . DOI:10.16561/j.cnki.xws.2017.03.02http://doi.org/10.16561/j.cnki.xws.2017.03.02 .

刘宁 , 崔丹丹 , 黎晨晨 . 纤维素酶制备香蕉皮纳米纤维素的工艺条件研究 . 中国食品添加剂 , 2018 . (2 ):112 -117 . DOI:10.3969/j.issn.1006-2513.2018.02.011http://doi.org/10.3969/j.issn.1006-2513.2018.02.011.

Ning LIU , Dandan CUI , Chenchen LI . Study on the process conditions of preparation of nano-cellulose in banana peel by cellulose . China Food Additives , 2018 . (2 ):112 -117 . DOI:10.3969/j.issn.1006-2513.2018.02.011http://doi.org/10.3969/j.issn.1006-2513.2018.02.011.

汪雪琴 , 卢麒麟 , 林凤采 , 等 . 纤维素酶解预处理辅助超声法制备竹浆纳米纤维素 . 农业工程学报 , 2018 . 34 (9 ):276 -284 . http://d.old.wanfangdata.com.cn/Periodical/nygcxb201809034http://d.old.wanfangdata.com.cn/Periodical/nygcxb201809034, .

Xueqin WANG , Qilin LU , Fengcai LIN , 等 . Preparation of cellulose nanofibrils from bamboo pulp by pretreatment combined with ultrasound method . Transactions of the Chinese Society of Agricultural Engineering , 2018 . 34 (9 ):276 -284 . http://d.old.wanfangdata.com.cn/Periodical/nygcxb201809034http://d.old.wanfangdata.com.cn/Periodical/nygcxb201809034, .

陈浩.纳米纤维素抗菌材料的制备及应用[D].济南: 齐鲁工业大学, 2017.

CHEN Hao. Preparation and application of nanocellulose based antibacterial materials[D]. Jinan: Qilu University of Technology, 2017.

曹菲 , 赵鑫 , 胡英成 , 等 . 基于离子液体的椰壳纤维纳米纤维素的制备与表征 . 林产化学与工业 , 2017 . 37 (5 ):139 -145 . DOI:10.3969/j.issn.0253-2417.2017.05.019http://doi.org/10.3969/j.issn.0253-2417.2017.05.019.

Fei CAO , Xin ZHAO , Yingcheng HU , 等 . Preparation characterization of nanocellulose from coconut husk fibers based on ionic liquids . Chemistry and Industry of Forest Products , 2017 . 37 (5 ):139 -145 . DOI:10.3969/j.issn.0253-2417.2017.05.019http://doi.org/10.3969/j.issn.0253-2417.2017.05.019.

张莉会 , 蔡芳 , 何建军 , 等 . 辐照对榨菜品质及其贮存效果的影响 . 辐射研究与辐射工艺学报 , 2017 . 35 (5 ):050401 DOI:10.11889/j.1000-3436.2017.rrj.35.050401http://doi.org/10.11889/j.1000-3436.2017.rrj.35.050401 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract436.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract436.shtml, .

Lihui ZHANG , Fang CAI , Jianjun HE , 等 . Effects of irradiation on the quality and storage time of mustard . Journal of Radiation Research and Radiation Processing , 2017 . 35 (5 ):050401 DOI:10.11889/j.1000-3436.2017.rrj.35.050401http://doi.org/10.11889/j.1000-3436.2017.rrj.35.050401 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract436.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract436.shtml, .

龙薇运.低剂量电子束辐照对蛤蜊保藏影响的研究[D].杭州: 浙江大学, 2014.

LONG Weiyun. Research on the effects of low dose electron beam irradiation on clam preservation[D]. Hangzhou: Zhejiang University, 2014.

张伯武 , 俞初红 , 沈蓉芳 , 等 . 伽马射线辐照技术制备石墨烯基功能材料的研究进展 . 辐射研究与辐射工艺学报 , 2017 . 35 (2 ):020101 DOI:10.11889/j.1000-3436.2017.rrj.35.020201http://doi.org/10.11889/j.1000-3436.2017.rrj.35.020201 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract384.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract384.shtml, .

Bowu ZHANG , Chuhong YU , Rongfang SHEN , 等 . Progress in research on preparation of grapheme-based functional materials using gamma-ray irradiation technology . Journal of Radiation Research and Radiation Processing , 2017 . 35 (2 ):020101 DOI:10.11889/j.1000-3436.2017.rrj.35.020201http://doi.org/10.11889/j.1000-3436.2017.rrj.35.020201 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract384.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract384.shtml, .

张茂江 , 胡江涛 , 王明磊 , 等 . 低能电子束辐射交联改性PP/LLDPE五层共挤POF热收缩膜的性能 . 高分子材料科学与工程 , 2018 . 34 (4 ):37 -42 . DOI:10.16865/j.cnki.1000-7555.2018.04.007http://doi.org/10.16865/j.cnki.1000-7555.2018.04.007 .

Maojiang ZHANG , Jiangtao HU , Minglei WANG , 等 . Properties of PP/LLDPE five-larers POF shrink film modified with low energy electron beam irradiation . Polymer Materials Science & Engineering , 2018 . 34 (4 ):37 -42 . DOI:10.16865/j.cnki.1000-7555.2018.04.007http://doi.org/10.16865/j.cnki.1000-7555.2018.04.007 .

马志远. 60Co-γ射线对室温固化耐温型低红外发射率涂层性能的影响[D].南京: 南京航空航天大学, 2016.

MA Zhiyuan. Effect of 60Co-γ ray on performance of low infrared emissivity coating curved at room temperature and applied at moderate temperature[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2016.

贾晓斌 , 彭佳 , 杜纪富 , 等 . 聚氨酯丙烯酸酯的电子束固化及其性能研究 . 辐射研究与辐射工艺学报 , 2015 . 33 (1 ):010303 DOI:10.11889/j.1000-3436.2015.rrj.33.010303http://doi.org/10.11889/j.1000-3436.2015.rrj.33.010303 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract222.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract222.shtml, .

Xiaobin JIA , Jia PENG , Jifu DU , 等 . Study on electronic-beam-cured aqueous us polyurethane acrylates system and its properties . Journal of Radiation Research and Radiation Processing , 2015 . 33 (1 ):010303 DOI:10.11889/j.1000-3436.2015.rrj.33.010303http://doi.org/10.11889/j.1000-3436.2015.rrj.33.010303 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract222.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract222.shtml, .

刘华平 , 胡晓丹 , 张晓红 , 等 . 伽玛射线辐照降解水溶液中土霉素及其降解路径的研究 . 辐射研究与辐射工艺学报 , 2015 . 33 (1 ):010301 DOI:10.11889/j.1000-3436.2015.rrj.33.010301http://doi.org/10.11889/j.1000-3436.2015.rrj.33.010301 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract219.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract219.shtml, .

Huaping LIU , Xiaodan HU , Xiaohong ZHANG , 等 . Study on γ-radiolytical degradation of oxytetracyline in aqueous solution and its degradation pathway . Journal of Radiation Research and Radiation Processing , 2015 . 33 (1 ):010301 DOI:10.11889/j.1000-3436.2015.rrj.33.010301http://doi.org/10.11889/j.1000-3436.2015.rrj.33.010301 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract219.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract219.shtml, .

徐培军 , 鲍阳阳 , 郑明 , 等 . 普施安红MX-5B的电子束辐照降解 . 上海大学学报(自然科学版) , 2015 . 21 (6 ):694 -700 . http://d.old.wanfangdata.com.cn/Periodical/shdxxb201506003http://d.old.wanfangdata.com.cn/Periodical/shdxxb201506003, .

Peijun XU , Yangyang BAO , Ming ZHENG , 等 . Degradation of procion Red MX-5B in aqueous solution using clectorn beam . Journal of Shanghai University (Natural Science Edition) , 2015 . 21 (6 ):694 -700 . http://d.old.wanfangdata.com.cn/Periodical/shdxxb201506003http://d.old.wanfangdata.com.cn/Periodical/shdxxb201506003, .

孙坚.微晶纤维素的辐射降解及超细处理[C]//中国核学会.中国核科学技术进展报告-中国核学会2009年学术年会论文集: 第一卷·第八册.北京: 原子能出版社, 2009: 5.

SUN Jian. Radiation degradation and ultrafine treatment of microcrystalline cellulose[C]//China Nuclear Society. China nuclear science and technology progress report-proceedings of the 2009 annual meeting of the Chinese Nuclear Society: Volum 1·Issue 8.Beijing: Atomic Energy Press, 2009: 5.

E M Kholodkova , A V Ponomarev . Combined effect of heat and radiation on degradation of cellulose . High Energy Chemistry , 2012 . 46 (4 ):292 -293 . DOI:10.1134/S0018143912040091http://doi.org/10.1134/S0018143912040091 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on degradation of methyl red dye wastewater by dielectric barrier discharge low temperature plasma

Study on the degradation characteristics and pathway of torasemide in water via electron beam irradiation

Study on irradiation degradation and antioxidant activity of Astragalus polysaccharide

Study on irradiation-induced-degradation of five fishery drugs in aqueous solution by ⁶⁰Co γ-rays

The effects of electron beam irradiation on sterilization and preservation of chilled pork

Related Author

No data

Related Institution

Nanjing RGE Membrane Separation Technology Co., Ltd.

Nanjing Tech University Pujiang Institute

School of Environmental and Chemical Engineering, Shanghai University

Irradiation Preservation Key Laboratory of Sichuan Province

Sichuan Institute of Atomic Energy

⁰