Effect of electron-beam irradiation on colority of printing-dyeing wastewater

Yuying XIE; Zuliang CHEN; Zhaolong LI; Yuehong ZHANG; Huaming WANG; Meiling SHEN

doi:10.11889/j.1000-3436.2018.rrj.36.060401

您当前的位置：

首页 >

文章列表页 >

Effect of electron-beam irradiation on colority of printing-dyeing wastewater

RADIATION TECHNOLOGY APPLICATION | 更新时间：2021-12-10

- Effect of electron-beam irradiation on colority of printing-dyeing wastewater
- Journal of Radiation Research and Radiation Processing Vol. 36, Issue 6, (2018)
- 作者机构：
  
  1.浙江省能源与核技术应用研究院杭州 310012
- 作者简介：
- 基金信息：
  
  the Science and Technology Planning Project of Zhejiang Province, China(2016F50011)
- DOI：10.11889/j.1000-3436.2018.rrj.36.060401
  CLC：
扫描看全文
Yuying XIE, Zuliang CHEN, Zhaolong LI, et al. Effect of electron-beam irradiation on colority of printing-dyeing wastewater. [J]. Journal of Radiation Research and Radiation Processing 36(6):060401-7(2018)
DOI：

Yuying XIE, Zuliang CHEN, Zhaolong LI, et al. Effect of electron-beam irradiation on colority of printing-dyeing wastewater. [J]. Journal of Radiation Research and Radiation Processing 36(6):060401-7(2018) DOI： 10.11889/j.1000-3436.2018.rrj.36.060401.

摘要

采用电子束辐照对印染废水处理工艺中主要阶段的废水进行了处理。并根据色度学原理，利用分光光度法测定水体的色度。经电子束辐照后，物化-生化处理后的水样在200 kGy时，色度可低至10度以下，脱色率达90%，目视比色时几乎与光学纯水无差别。经电子束辐照后，物化处理后的水样在100 kGy时，色度降至原液色度的46%；200 kGy时，色度降至50度左右，为原液色度的18%。电子束辐照对传统印染工艺主要阶段的废水脱色均有明显的效果，将电子束辐照与印染废水传统处理工艺相结合，可实现对印染废水色度的深度处理。

Abstract

The effect of electron-beam irradiation on the colority of the wastewater extracted by different methods in traditional physicochemical-biochemical processes was studied. Moreover, spectrophotometry was employed to determine the water colority of printing-dyeing wastewater. The results showed that the colority of the physicochemical-biochemical-treated wastewater was less than 10 Hazen at 200 kGy with up to 90% decolorization rate and that it was difficult to distinguish from pure water. For the physicochemical-treated wastewater, the decolorization rate was 46% at 100 kGy and the colority was about 50 Hazen at 200 kGy with up to 82% decolorization rate. Electron-beam irradiation had a positive effect on different kinds of dyeing wastewater. A combined treatment of electron-beam irradiation and a traditional physicochemical-biochemical process is recommended for the advanced treatment of dyeing wastewater.

关键词

电子束辐照物化处理生化处理色度印染废水

Keywords

Electron-beam irradiationPhysicochemical treatmentBiochemical treatmentColorityPrinting-dyeing wastewater

references

董殿波 . 印染废水处理技术研究进展 . 染料与染色 , 2015 . 52 (4 ):56 -62 . http://d.old.wanfangdata.com.cn/Periodical/fzxb200701032http://d.old.wanfangdata.com.cn/Periodical/fzxb200701032.

Dianbo DONG . Application of EBIS process in treatment of dyeing wastewater . Dyestuffs and Coloration , 2015 . 52 (4 ):56 -62 . http://d.old.wanfangdata.com.cn/Periodical/fzxb200701032http://d.old.wanfangdata.com.cn/Periodical/fzxb200701032.

陈晓燕 , 何秉宇 , 张雯 . 印染废水处理研究进展 . 纺织导报 , 2018 . (3 ):60 -62 . DOI:10.16481/j.cnki.ctl.2018.03.012http://doi.org/10.16481/j.cnki.ctl.2018.03.012 .

Xiaoyan CHEN , Bingyu HE , Wen ZHANG . Research progress on the treatment of printing and dyeing wastewater . China Textile Leader , 2018 . (3 ):60 -62 . DOI:10.16481/j.cnki.ctl.2018.03.012http://doi.org/10.16481/j.cnki.ctl.2018.03.012 .

戴日成 , 张统 , 郭茜 , 等 . 印染废水水质特征及处理技术综述 . 给水排水 , 2000 . 26 (10 ):33 -37 . DOI:10.13789/j.cnki.wwe1964.2000.10.011http://doi.org/10.13789/j.cnki.wwe1964.2000.10.011 .

Richeng DAI , Tong ZHANG , Qian GUO , 等 . Summary of printing-dyeing wastewater treatment technology . Water & Wastewater Engineering , 2000 . 26 (10 ):33 -37 . DOI:10.13789/j.cnki.wwe1964.2000.10.011http://doi.org/10.13789/j.cnki.wwe1964.2000.10.011 .

张宇峰 , 滕洁 , 张雪英 , 等 . 印染废水处理技术的研究进展 . 工业水处理 , 2003 . 23 (4 ):23 -27 . DOI:10.3969/j.issn.1005-829X.2003.04.006http://doi.org/10.3969/j.issn.1005-829X.2003.04.006.

Yufeng ZHANG , Jie TENG , Xueying ZHANG , 等 . Progress of the researches on dyeing wastewater treatment techniques . Industrial Water Treatment , 2003 . 23 (4 ):23 -27 . DOI:10.3969/j.issn.1005-829X.2003.04.006http://doi.org/10.3969/j.issn.1005-829X.2003.04.006.

T H Kim , J K Lee , M J Lee . Biodegradability enhancement of textile waste-water by electron beam irradiation . Radiation Physics and Chemistry , 2007 . 76 (6 ):1037 -1041 . DOI:10.1016/j.radphyschem.2006.10.001http://doi.org/10.1016/j.radphyschem.2006.10.001 .

M L Botelho , J Branco , C Freitas , 等 . Implementation of ionising radiation on wastewater treatment:the portuguese study case, radiation treatment of polluted water and wastewater , :Vienna IAEA , 2008 . 148 -159.

S I Borrely , A C Cruz , N L Delmnstm , 等 . Radiation process of sewage and sludge . Progress in Nuclear Energy , 1998 . 33 (1-2 ):3 -21 . DOI:10.1016/S0149-1970(97)87287-3http://doi.org/10.1016/S0149-1970(97)87287-3 .

Trojanowicz M, Drzewicz P, Bojanowskaczajka A, et al. Application of ionizing radiation for removal of pesticides from groundwaters and wastes[M]. IAEA Technical Document-1598, 2008: 115-140.https://www.researchgate.net/publication/234176699_APPLICATION_OF_IONIZING_RADIATION_FOR_DEGRADATION_OF_ORGANIC_POLLUTANTS_IN_WATERS_AND_WASTES

杨睿媛 , 王敏 , 王文峰 , 等 . 活性红M-3BE的辐照降解研究 . 环境科学与技术 , 2005 . 28 (增刊 ):1 -3 . DOI:10.3969/j.issn.1003-6504.2005.z1.001http://doi.org/10.3969/j.issn.1003-6504.2005.z1.001 .

Ruiyuan YANG , Min WANG , Wenfeng WANG , 等 . Radiolysis of reactive red m-3BE in aqueous solution by electron accelerator . Environmental Science & Technology , 2005 . 28 (Suppl. ):1 -3 . DOI:10.3969/j.issn.1003-6504.2005.z1.001http://doi.org/10.3969/j.issn.1003-6504.2005.z1.001 .

王敏 , 朱志远 , 杨睿嫒 , 等 . 电子束辐照处理水溶液中的活性染料 . 核技术 , 2005 . 28 (1 ):40 -45 . DOI:10.3321/j.issn:0253-3219.2005.01.010http://doi.org/10.3321/j.issn:0253-3219.2005.01.010 .

Min WANG , Zhiyuan ZHU , Ruiyuan YANG , 等 . Electron beam irradiation treatment of reactive dyes in aqueous solution . Nuclear Techniques , 2005 . 28 (1 ):40 -45 . DOI:10.3321/j.issn:0253-3219.2005.01.010http://doi.org/10.3321/j.issn:0253-3219.2005.01.010 .

K Dajka , E Takacs , D Solpan , 等 . High-energy irradiation treatment of aqueous solutions of C.I. Reactive Black 5 azo dye:pulse radiolysis experiments . Radiation Physics and Chemistry , 2003 . 67 535 -538 . DOI:10.1016/S0969-806X(03)00101-4http://doi.org/10.1016/S0969-806X(03)00101-4 .

M Wang , R Yang , W Wang , 等 . Radiation-induced decomposition and decoloration of reactive dyes in the presence of H2O2 . Radiation Physics and Chemistry , 2006 . 75 (2 ):286 -291 . DOI:10.1016/j.radphyschem.2005.08.012http://doi.org/10.1016/j.radphyschem.2005.08.012 .

中华人民共和国环境保护局. GB 11903-1989水质色度的测定[S].北京: 中国标准出版社, 1990.

Environmental Protection Bureau of the People's Republic of China. GB 11903-1989 Water quality-determination of colority[S]. Beijing: Standards Press of China, 1990.

郜洪文 . 分光光度法测定工业废水色度研究 . 环境工程 , 1993 . 11 (5 ):44 -47 . DOI:10.13205/j.hjgc.1993.05.010http://doi.org/10.13205/j.hjgc.1993.05.010 .

Hongwen HAO . Spectrophotometry chroma of industrial waste water . Environmental Engineering , 1993 . 11 (5 ):44 -47 . DOI:10.13205/j.hjgc.1993.05.010http://doi.org/10.13205/j.hjgc.1993.05.010 .

刘春 , 郭春娟 . 用分光光度计测定地面水色度 . 环境科技 , 1994 . 14 (1 ):75 -76 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=QK199400830757http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=QK199400830757.

Chun LIU , Chunjuan GUO . Determination of surface water colority by spectrophotometer . Environmental Science and Technology , 1994 . 14 (1 ):75 -76 . http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=QK199400830757http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=QK199400830757.

马登军 . 分光光度法快速测定天然水色度 . 中国环境监测 , 1993 . 9 (4 ):15 -16 . DOI:10.19316/j.issn.1002-6002.1993.04.009http://doi.org/10.19316/j.issn.1002-6002.1993.04.009 .

Dengjun MA . Rapid determination of natural water colority by spectrophotometric method . Environmental Monitoring in China , 1993 . 9 (4 ):15 -16 . DOI:10.19316/j.issn.1002-6002.1993.04.009http://doi.org/10.19316/j.issn.1002-6002.1993.04.009 .

王永琴 , 苏筱军 . 分光光度法测定水中色度探讨 . 预防医学 , 1997 . 3 (2 ):146 DOI:10.16406/j.pmt.issn.1672-9153.1997.02.048http://doi.org/10.16406/j.pmt.issn.1672-9153.1997.02.048 .

Yongqin WANG , Xiaojun SU . Determination of chromaticity of water by spectrophotometric method . Preventive Medicine , 1997 . 3 (2 ):146 DOI:10.16406/j.pmt.issn.1672-9153.1997.02.048http://doi.org/10.16406/j.pmt.issn.1672-9153.1997.02.048 .

于夕娟 . 水中色度的分光光度测定法 . 职业与健康 , 2008 . 24 (15 ):1515 -1516 . DOI:10.16406/j.pmt.issn.1672-9153.1997.02.048http://doi.org/10.16406/j.pmt.issn.1672-9153.1997.02.048 .

Xijuan YU . Spectrophotometry in the determination of water chroma . Occupation and Health , 2008 . 24 (15 ):1515 -1516 . DOI:10.16406/j.pmt.issn.1672-9153.1997.02.048http://doi.org/10.16406/j.pmt.issn.1672-9153.1997.02.048 .

曾凡亮 , 罗仙桃 . 分光光度法测定水样的色度 . 工业水处理 , 2006 . 26 (9 ):69 -73 . DOI:10.13329/j.cnki.zyyjk.2008.15.002http://doi.org/10.13329/j.cnki.zyyjk.2008.15.002 .

Fanliang ZENG , Xiantao LUO . Determination of the colority of water samples by spectrophotometry . Industrial Water Treatment , 2006 . 26 (9 ):69 -73 . DOI:10.13329/j.cnki.zyyjk.2008.15.002http://doi.org/10.13329/j.cnki.zyyjk.2008.15.002 .

毛善巧 , 杨锋 , 黄永春 , 等 . 分光光度法测定水力空化对绿原酸的影响 . 中国食品添加剂 , 2017 . (6 ):184 -189 . DOI:10.3969/j.issn.1006-2513.2017.06.023http://doi.org/10.3969/j.issn.1006-2513.2017.06.023.

Shanqiao MAO , Feng YANG , Yongchun Huang , 等 . Determination of the effect of hydrodynamic cavitation on chlorogenic acid by spectrophotometry . China Food Additives , 2017 . (6 ):184 -189 . DOI:10.3969/j.issn.1006-2513.2017.06.023http://doi.org/10.3969/j.issn.1006-2513.2017.06.023.

陈洪雷 , 杨桂花 , 陈嘉川 , 等 . 比值-导数光谱法测定APMP制浆废水的色度 . 林产化学与工业 , 2014 . 34 (5 ):35 -40 . http://d.old.wanfangdata.com.cn/Periodical/lchxygy201405006http://d.old.wanfangdata.com.cn/Periodical/lchxygy201405006.

Honglei CHEN , Guihua YANG , Jiachuan CHEN , 等 . Chroma determination of APMP pulping wastewater by ratio-derivative spectrometry . Chemistry and Industry of Forest Products , 2014 . 34 (5 ):35 -40 . http://d.old.wanfangdata.com.cn/Periodical/lchxygy201405006http://d.old.wanfangdata.com.cn/Periodical/lchxygy201405006.

陈强 , 罗亮 , 曾正中 , 等 . 分光光度法测定水体色度的一种新方法 . 甘肃环境研究与监测 , 2003 . 16 (4 ):342 -343 . http://www.cnki.com.cn/Article/CJFDTOTAL-GSHJ200304018.htmhttp://www.cnki.com.cn/Article/CJFDTOTAL-GSHJ200304018.htm.

Qiang CHEN , Liang LUO , Zhengzhong ZENG , 等 . A new method of water colority determination by spectrophotometer . Gansu Environmental Study and Monitoring , 2003 . 16 (4 ):342 -343 . http://www.cnki.com.cn/Article/CJFDTOTAL-GSHJ200304018.htmhttp://www.cnki.com.cn/Article/CJFDTOTAL-GSHJ200304018.htm.

余潘 , 沈为民 , 黄杰 , 等 . 可见区分光光度法测量水体色度 . 光学技术 , 2011 . 37 (5 ):551 -555 . DOI:10.13741/j.cnki.11-1879/o4.2011.05.021http://doi.org/10.13741/j.cnki.11-1879/o4.2011.05.021 .

Pan YU , Weimin SHEN , Jie HUANG , 等 . Determination of water colority by spectrophotometry in visible spectrum . Optical Technique , 2011 . 37 (5 ):551 -555 . DOI:10.13741/j.cnki.11-1879/o4.2011.05.021http://doi.org/10.13741/j.cnki.11-1879/o4.2011.05.021 .

黄杰 , 沈为民 , 楼俊 , 等 . 基于光谱及色差计算测定水质的色度 . 光谱实验室 , 2012 . 29 (6 ):3399 -3403 . DOI:10.3969/j.issn.1004-8138.2012.06.029http://doi.org/10.3969/j.issn.1004-8138.2012.06.029 .

Jie HUANG , Weimin SHEN , Jun LOU , 等 . Determination of water colority based on spectrum and calculation of color difference . Chinese Journal of Spectroscopy Laboratory , 2012 . 29 (6 ):3399 -3403 . DOI:10.3969/j.issn.1004-8138.2012.06.029http://doi.org/10.3969/j.issn.1004-8138.2012.06.029 .

沈为民 , 余潘 , 黄杰 , 等 . 水质色度的色差测量方法 . 计量学报 , 2013 . 34 (4 ):320 -324 . DOI:10.3969/j.issn.1000-1158.2013.04.04http://doi.org/10.3969/j.issn.1000-1158.2013.04.04 .

Weimin SHEN , Pan YU , Jie HUANG , 等 . Water colority determination based on color difference . Acta Metrologica Sinica , 2013 . 34 (4 ):320 -324 . DOI:10.3969/j.issn.1000-1158.2013.04.04.SHENissn.1000-1158.2013.04.04http://doi.org/10.3969/j.issn.1000-1158.2013.04.04.SHENissn.1000-1158.2013.04.04 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Preparation of a freestanding graphene oxide forward osmosis membrane by electron-beam irradiation and its acid recovery performance

Influence of electron-beam irradiation on amino acids and protein structure

Structure and thermal properties of nylon 12 irradiated by electron-beam

Preparation of micron-hole array on polypropylene membranes by electro beam irradiation

Preparation of chelating fibers —modification of poly(vinyl formal) fiber

Related Author

No data

Related Institution

College of Material Science and Engineering, Wuhan Institute of Technology

Shanghai Institute of Applied Physics, Chinese Academy of Sciences

University of Chinese Academy of Sciences

Institute for Agri-food Quality Standards and Technology, Shanghai Academy of Agricultural Sciences

Agricultural Products Quality and Safety Risk Assessment Laboratory Ministry of Agriculture and Rural Affaies of the People's Republic of China

⁰