电子束辐照制备纳米纤维素

崔国士; 杨蓓; 赵红英; 束兴娟; 樊茹

doi:10.11889/j.1000-3436.2018.rrj.36.050302

您当前的位置：

首页 >

文章列表页 >

电子束辐照制备纳米纤维素

辐射化学 | 更新时间：2021-12-10

- 电子束辐照制备纳米纤维素
- Preparation of nano-cellulose by electron beam radiation
- 辐射研究与辐射工艺学报 2018年36卷第5期
- 作者机构：
  
  1.河南科高辐射化工科技有限公司洛阳 471000
  2.河南省辐射化学新材料重点实验室洛阳 471000
- 作者简介：
  
  [ "崔国士, 男, 1964年9月出生, 2010年于东华大学材料科学与工程学院获博士学位, 研究员, E-mail: cuiguoshi2008@126.com", "CUI Guoshi (male) was born in September 1964, and received his doctor's degree from the College of Material Science and Engineering, Donghua University in 2010, professor, E-mail: cuiguoshi2008@126.com" ]
- 基金信息：
  
  河南省科技创新人才项目(184200510025);河南省科学院预先研究项目(豫财预[2016]80号)
- DOI：10.11889/j.1000-3436.2018.rrj.36.050302
  中图分类号：
扫描看全文
崔国士, 杨蓓, 赵红英, 等. 电子束辐照制备纳米纤维素[J]. 辐射研究与辐射工艺学报, 2018,36(5):050302-5.

Guoshi CUI, Bei YANG, Hongying ZHAO, et al. Preparation of nano-cellulose by electron beam radiation[J]. Journal of Radiation Research and Radiation Processing, 2018,36(5):050302-5.
崔国士, 杨蓓, 赵红英, 等. 电子束辐照制备纳米纤维素[J]. 辐射研究与辐射工艺学报, 2018,36(5):050302-5. DOI： 10.11889/j.1000-3436.2018.rrj.36.050302.

Guoshi CUI, Bei YANG, Hongying ZHAO, et al. Preparation of nano-cellulose by electron beam radiation[J]. Journal of Radiation Research and Radiation Processing, 2018,36(5):050302-5. DOI： 10.11889/j.1000-3436.2018.rrj.36.050302.

摘要

以纤维素浆粕为原料，经电子束辐照降解、湿法磨浆、高压均质处理，成功制备出纳米纤维素分散液。结果表明，纳米纤维素制备优化工艺为：纤维分散液质量分数为2%，磨浆次数为5次，NaOH质量分数为5%，吸收剂量为100 kGy，由此制备出的纳米纤维素直径在60 nm左右，长度为1 μm左右。

Abstract

Cellulose pulp was used as raw material and a nano-cellulose dispersion was successfully prepared via electron beam radiation degradation, wet refining, and high-pressure homogenization treatment. The results showed that the parameters in the nano-cellulose preparation optimization process were as follows:the fiber dispersion concentration was 2%, refining frequency was 5 times, alkali concentration was 5%, and absorbed dose was 100 kGy. The diameter and length of the prepared nano-cellulose were approximately 60 nm and 1 μm, respectively.

关键词

电子束辐照降解纳米纤维素

Keywords

Electron beam radiationDegradationNano-cellulose

references

吴清林 , 梅长彤 , 韩景泉 , 等 . 纳米纤维素制备技术及产业化现状 . 林业工程学报 , 2018 . 3 (1 ):1 -9 . DOI:10.13360/j.issn.2096-1359.2018.01.001http://doi.org/10.13360/j.issn.2096-1359.2018.01.001 .

Qinglin WU , Changtong MEI , Jingquan HAN , 等 . Preparation technology and industrization status of nanocellulose . Jouranl of Forestry Engineering , 2018 . 3 (01 ):1 -9 . DOI:10.13360/j.issn.2096-1359.2018.01.001http://doi.org/10.13360/j.issn.2096-1359.2018.01.001 .

李逸 , 王可鑫 , 郑卓辉 , 等 . 纳米纤维素复合材料的应用进展 . 纸和造纸 , 2016 . 35 (12 ):26 -28 . DOI:10.13472/j.ppm.2016.12.007http://doi.org/10.13472/j.ppm.2016.12.007 .

Yi LI , Kexin WANG , Zhuohui ZHENG , 等 . Application progress of nano-cellulose composites . Paper and Paper Making , 2016 . 35 (12 ):26 -28 . DOI:10.13472/j.ppm.2016.12.007http://doi.org/10.13472/j.ppm.2016.12.007 .

徐威宇.植物纤维原料制备纳米纤维素的研究[D].广州: 华南理工大学, 2016.

XU Weiyu. The research of nanocellulose fiber raw material[D]. Guangzhou: South China University of Technology, 2016.

孙启伟.绿色法制备纳米木薯渣及其在橡胶复合体系的应用初探[D].南宁: 广西大学, 2017.

SUN Qiwei. Green fabrication of nano cassava dregs and its potential application in rubber[D]. Nanning: Guangxi University, 2017.

欧华杰 , 陈港 , 蒋晨颖 , 等 . NMMO预处理制备微纳米纤维素及其在纸页增强中的应用 . 造纸科学与技术 , 2017 . 36 (6 ):57 -60 . DOI:10.19696/j.issn1671-4571.2017.06.013http://doi.org/10.19696/j.issn1671-4571.2017.06.013 .

Huajie OU , Gang CHEN , Chenying JIANG , 等 . Preparation of cellulose nanofibrils and its application in paper coating . Paper Science & Technology , 2017 . 36 (6 ):57 -60 . DOI:10.19696/j.issn1671-4571.2017.06.013http://doi.org/10.19696/j.issn1671-4571.2017.06.013 .

申玲玲 , 张放 , 任浩 , 等 . 氧化纤维对纳米纤维素气凝胶微球的影响 . 纤维素科学与技术 , 2017 . 25 (3 ):1 -7 . DOI:10.16561/j.cnki.xws.2017.03.02http://doi.org/10.16561/j.cnki.xws.2017.03.02 .

Lingling SHEN , Fang ZHANG , Hao REN , 等 . Effect of oxidized fibril on cellulose nanofiber based aerogel microsphere . Journal of Cellulose Science and Technology , 2017 . 25 (3 ):1 -7 . DOI:10.16561/j.cnki.xws.2017.03.02http://doi.org/10.16561/j.cnki.xws.2017.03.02 .

刘宁 , 崔丹丹 , 黎晨晨 . 纤维素酶制备香蕉皮纳米纤维素的工艺条件研究 . 中国食品添加剂 , 2018 . (2 ):112 -117 . DOI:10.3969/j.issn.1006-2513.2018.02.011http://doi.org/10.3969/j.issn.1006-2513.2018.02.011.

Ning LIU , Dandan CUI , Chenchen LI . Study on the process conditions of preparation of nano-cellulose in banana peel by cellulose . China Food Additives , 2018 . (2 ):112 -117 . DOI:10.3969/j.issn.1006-2513.2018.02.011http://doi.org/10.3969/j.issn.1006-2513.2018.02.011.

汪雪琴 , 卢麒麟 , 林凤采 , 等 . 纤维素酶解预处理辅助超声法制备竹浆纳米纤维素 . 农业工程学报 , 2018 . 34 (9 ):276 -284 . http://d.old.wanfangdata.com.cn/Periodical/nygcxb201809034http://d.old.wanfangdata.com.cn/Periodical/nygcxb201809034, .

Xueqin WANG , Qilin LU , Fengcai LIN , 等 . Preparation of cellulose nanofibrils from bamboo pulp by pretreatment combined with ultrasound method . Transactions of the Chinese Society of Agricultural Engineering , 2018 . 34 (9 ):276 -284 . http://d.old.wanfangdata.com.cn/Periodical/nygcxb201809034http://d.old.wanfangdata.com.cn/Periodical/nygcxb201809034, .

陈浩.纳米纤维素抗菌材料的制备及应用[D].济南: 齐鲁工业大学, 2017.

CHEN Hao. Preparation and application of nanocellulose based antibacterial materials[D]. Jinan: Qilu University of Technology, 2017.

曹菲 , 赵鑫 , 胡英成 , 等 . 基于离子液体的椰壳纤维纳米纤维素的制备与表征 . 林产化学与工业 , 2017 . 37 (5 ):139 -145 . DOI:10.3969/j.issn.0253-2417.2017.05.019http://doi.org/10.3969/j.issn.0253-2417.2017.05.019.

Fei CAO , Xin ZHAO , Yingcheng HU , 等 . Preparation characterization of nanocellulose from coconut husk fibers based on ionic liquids . Chemistry and Industry of Forest Products , 2017 . 37 (5 ):139 -145 . DOI:10.3969/j.issn.0253-2417.2017.05.019http://doi.org/10.3969/j.issn.0253-2417.2017.05.019.

张莉会 , 蔡芳 , 何建军 , 等 . 辐照对榨菜品质及其贮存效果的影响 . 辐射研究与辐射工艺学报 , 2017 . 35 (5 ):050401 DOI:10.11889/j.1000-3436.2017.rrj.35.050401http://doi.org/10.11889/j.1000-3436.2017.rrj.35.050401 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract436.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract436.shtml, .

Lihui ZHANG , Fang CAI , Jianjun HE , 等 . Effects of irradiation on the quality and storage time of mustard . Journal of Radiation Research and Radiation Processing , 2017 . 35 (5 ):050401 DOI:10.11889/j.1000-3436.2017.rrj.35.050401http://doi.org/10.11889/j.1000-3436.2017.rrj.35.050401 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract436.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract436.shtml, .

龙薇运.低剂量电子束辐照对蛤蜊保藏影响的研究[D].杭州: 浙江大学, 2014.

LONG Weiyun. Research on the effects of low dose electron beam irradiation on clam preservation[D]. Hangzhou: Zhejiang University, 2014.

张伯武 , 俞初红 , 沈蓉芳 , 等 . 伽马射线辐照技术制备石墨烯基功能材料的研究进展 . 辐射研究与辐射工艺学报 , 2017 . 35 (2 ):020101 DOI:10.11889/j.1000-3436.2017.rrj.35.020201http://doi.org/10.11889/j.1000-3436.2017.rrj.35.020201 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract384.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract384.shtml, .

Bowu ZHANG , Chuhong YU , Rongfang SHEN , 等 . Progress in research on preparation of grapheme-based functional materials using gamma-ray irradiation technology . Journal of Radiation Research and Radiation Processing , 2017 . 35 (2 ):020101 DOI:10.11889/j.1000-3436.2017.rrj.35.020201http://doi.org/10.11889/j.1000-3436.2017.rrj.35.020201 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract384.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract384.shtml, .

张茂江 , 胡江涛 , 王明磊 , 等 . 低能电子束辐射交联改性PP/LLDPE五层共挤POF热收缩膜的性能 . 高分子材料科学与工程 , 2018 . 34 (4 ):37 -42 . DOI:10.16865/j.cnki.1000-7555.2018.04.007http://doi.org/10.16865/j.cnki.1000-7555.2018.04.007 .

Maojiang ZHANG , Jiangtao HU , Minglei WANG , 等 . Properties of PP/LLDPE five-larers POF shrink film modified with low energy electron beam irradiation . Polymer Materials Science & Engineering , 2018 . 34 (4 ):37 -42 . DOI:10.16865/j.cnki.1000-7555.2018.04.007http://doi.org/10.16865/j.cnki.1000-7555.2018.04.007 .

马志远. 60Co-γ射线对室温固化耐温型低红外发射率涂层性能的影响[D].南京: 南京航空航天大学, 2016.

MA Zhiyuan. Effect of 60Co-γ ray on performance of low infrared emissivity coating curved at room temperature and applied at moderate temperature[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2016.

贾晓斌 , 彭佳 , 杜纪富 , 等 . 聚氨酯丙烯酸酯的电子束固化及其性能研究 . 辐射研究与辐射工艺学报 , 2015 . 33 (1 ):010303 DOI:10.11889/j.1000-3436.2015.rrj.33.010303http://doi.org/10.11889/j.1000-3436.2015.rrj.33.010303 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract222.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract222.shtml, .

Xiaobin JIA , Jia PENG , Jifu DU , 等 . Study on electronic-beam-cured aqueous us polyurethane acrylates system and its properties . Journal of Radiation Research and Radiation Processing , 2015 . 33 (1 ):010303 DOI:10.11889/j.1000-3436.2015.rrj.33.010303http://doi.org/10.11889/j.1000-3436.2015.rrj.33.010303 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract222.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract222.shtml, .

刘华平 , 胡晓丹 , 张晓红 , 等 . 伽玛射线辐照降解水溶液中土霉素及其降解路径的研究 . 辐射研究与辐射工艺学报 , 2015 . 33 (1 ):010301 DOI:10.11889/j.1000-3436.2015.rrj.33.010301http://doi.org/10.11889/j.1000-3436.2015.rrj.33.010301 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract219.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract219.shtml, .

Huaping LIU , Xiaodan HU , Xiaohong ZHANG , 等 . Study on γ-radiolytical degradation of oxytetracyline in aqueous solution and its degradation pathway . Journal of Radiation Research and Radiation Processing , 2015 . 33 (1 ):010301 DOI:10.11889/j.1000-3436.2015.rrj.33.010301http://doi.org/10.11889/j.1000-3436.2015.rrj.33.010301 http://www.j.sinap.ac.cn/fushe/CN/abstract/abstract219.shtmlhttp://www.j.sinap.ac.cn/fushe/CN/abstract/abstract219.shtml, .

徐培军 , 鲍阳阳 , 郑明 , 等 . 普施安红MX-5B的电子束辐照降解 . 上海大学学报(自然科学版) , 2015 . 21 (6 ):694 -700 . http://d.old.wanfangdata.com.cn/Periodical/shdxxb201506003http://d.old.wanfangdata.com.cn/Periodical/shdxxb201506003, .

Peijun XU , Yangyang BAO , Ming ZHENG , 等 . Degradation of procion Red MX-5B in aqueous solution using clectorn beam . Journal of Shanghai University (Natural Science Edition) , 2015 . 21 (6 ):694 -700 . http://d.old.wanfangdata.com.cn/Periodical/shdxxb201506003http://d.old.wanfangdata.com.cn/Periodical/shdxxb201506003, .

孙坚.微晶纤维素的辐射降解及超细处理[C]//中国核学会.中国核科学技术进展报告-中国核学会2009年学术年会论文集: 第一卷·第八册.北京: 原子能出版社, 2009: 5.

SUN Jian. Radiation degradation and ultrafine treatment of microcrystalline cellulose[C]//China Nuclear Society. China nuclear science and technology progress report-proceedings of the 2009 annual meeting of the Chinese Nuclear Society: Volum 1·Issue 8.Beijing: Atomic Energy Press, 2009: 5.

E M Kholodkova , A V Ponomarev . Combined effect of heat and radiation on degradation of cellulose . High Energy Chemistry , 2012 . 46 (4 ):292 -293 . DOI:10.1134/S0018143912040091http://doi.org/10.1134/S0018143912040091 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

介质阻挡放电低温等离子体降解甲基红模拟染料废水的研究

电子束辐照降解水溶液中托拉塞米的特性和途径

辐照降解黄芪多糖及其抗氧化活性研究

⁶⁰Co γ射线辐照五种常见渔药在水溶液中降解作用的研究

电子束辐照对冷却猪肉杀菌保鲜效果的研究